Hacker News Reader

Comment by Scoundreller | Hacker News Reader

EVs can be pretty bad for tire wear, not just due to vehicle weight, but the amount of torque available (and consistently available) that leaves most ICE vehicles in the dust.

Depends on driving style of course

View on HN

Sounds like emission standards need to be updated to include everything coming off a vehicle, not just out of the tail pipe.

It would incentivise clean disk materials and regenerative braking.

EURO 7 does include limits on breaks and tyre pollution.

Emissions standards have been deleted. Finally. I'm convinced they were going to greatly increase the environmental issues. After having improved emissions for decades they had no where else to improve and started building really complex engines with extreme maintenance requirements and very low reliability compared to the late 1990s. Modern trucks are throw aways compared to mid-1990s Ford and late 1990s GM. Nissan went out of business and Toyota isn't much of a player for towing capacity and value. Stellantis products have been a joke for years except for maybe the Charger and Wrangler for a time. Lots of high dollar junk being foisted on consumers right now.

Are you sure the blame is with the EPA and not the desire for ever increasing profit margins?

Seems cheaping out on quality parts is more likely to be the root of the issue than emissions standards.

I don't quite understand... you're saying it's a good thing if car manufacturers are allowed to pollute as much as they want in a race to the bottom? You prefer reliability in your vehicles over your children's health?

Could you clarify your position a bit?

If you have an EV and you care about health and the environment, use regenerative braking as much as humanly possible.

Hint: driving fast or tailgating both increase the odds you'll have to use the friction brakes.

The comment you replied to mentioned EV tire wear, not brake dust. The heavy weight of EVs due to the batteries is always going to cause more tire pollution.

E.g., Ford F-150 Ford Lightning has a curb weight of up to 6,500 lbs, which compares to the regular F-150's curb weight that ranges from anywhere between 4,021 lbs and 5,014 lbs. The Rivian R1T is 7,148 lbs.

That's more an argument against SUVs and heavy pickup trucks than against EVs, though.

Well yes, but even the Renault Zoe at 3,236lbs is much heavier than the Renault Clio (2,161–2,361lbs) it is based on.

Heavier weight alone however doesn't necessarily cause more tire wear though. The Toyota Prius came with hard-compound tires (good for low fuel consumption and high mileage, not for racing).

Interesting, my 2011 F150 is about 6200 pounds. Didn’t they switch to aluminum bodies in 2015 or so?

I like how much the EV interfaces gamify using the regenerative braking to encourage its use: regen indicators, miles per kw per trip, etc.

FWIW, I took my EV in for a maintenance interval (waste of money BTW - this thing is indestructable), and the mechanic remarked that the brakes looked new. It's 1.5 years old, with factory brakes.

Single-pedal mode does the rest. Not only does this make the car easier to drive, but you can hit a sweet spot where you never really use the brakes.

This. I treat it as a failure if I have to brake. My original tires are still good after 3 years as well

Also regenerative breaking exerts force which leads to particle emissions from the tires. Breaking earlier and slower also helps when you otherwise would have stayed in the range where you can break regeneratively.

I always assumed EVs use regenerative braking as much as possible on their own.

They do. But if you brake too agressively, they switch to friction brakes. It pays off to avoid this: more mileage, marginally lower charging expense, lower cost on brake maintenance and fewer complaints from passengers.

Apparently you need to use the friction brakes now and then so they don’t degrade early, which could be a safety issue. I think as long as you’re using the car frequently it’s incredibly unlikely to be a problem though.

Not sure about all EVs and hybrids, but for Prius the friction brakes were used below a given speed as then regeneration becomes inefficient (as does stopping power). If you pay close attention, you might notice the transition.

Yup. I only use my car infrequently and it sits there with the handbrake on, when I do take it out often the rotors have rusted just slightly, meaning I get a "thunk thunk thunk" until I brake hard a couple times.

I think it's fine, in an EV just give your physical brakes a good test/try out when starting a journey in the car, especially if it has been sat for a while.

I imagine there to be a sweet spot with friction breaks where it grinds the hardest, I imagine it to be when one breaks gently.

"It pays off to avoid this: more mileage, marginally lower charging expense, lower cost on brake maintenance and fewer complaints from passengers."

Regen braking wears the hell out of your battery. That few hundred you saved on brake changes just cost you a tens of thousands of dollars on a premature battery replacement.

Source for your ridiculous claim?

I'm not sure why they think regenerative breaking is worse than any other charging modality.

It's an added charge cycle on the battery. A guy in San Diego does full EIS and more for EV cells. His data shows multiple shorter recharge cycles wear the battery down faster, no matter what range you try restricting the recharging to. Same data shows that the batteries are better when conditioned harder on their first charge, gaining much better cycle performance and count, at a minimal sacrifice of capacity.

And this exact same thing coincides DIRECTLY with my lithium-powered portable lighting, so I'm pretty up-to-date on very top-level research, because I hire this same person.

His name is Luke. You'll see him all over the globe doing lithium EV research and testing.

Most EVs will not use regenerative braking when the battery is over 80% which is where the damage mostly happens

Really curious about this, since regen braking is Standard on all EVs

A charge cycle is a charge cycle, regardless. The wear and tear that occurs during is cumulative and doesn't just magically disappear when restricted to a certain level of battery depletion.

No experience with EVs, but Toyota hybrids use regenerative braking a lot. They also teach me to accelerate gently. Quite the opposite of Tesla with their "ludicrous mode" encouraging extreme acceleration. But I have no idea how well those brake.

Most don’t. Not all have heatpumps either. In fact anything outside Tesla is still garbage.

The problem is that not all cars correctly illuminate the brake lights when regenerative braking is in effect.

same problem on my manual transmission (and there aren't many of those left in north america)

I doubt that this is really the case (brake lights will be connected to brake pedal, regardless of mode).

For motorcycles (not using regenerative braking, but engine braking which is quite effective there) this however is a problem. Every once in a while I woke a sleepy tailgater with that. Fortunately all sleepy tailgaters did wake up in time.

This is why Tesla’s are best selling EVs. Only cynics and idiots buy anything else. Either way I am deeply sorry for them.

Thanks for your deep sorrow for this idiotic cynical nissan leaf owner. Love you too

Leaf would've been decent if not battery health issue and crazy charging port. Cleary Nissan doesn't want it so succeed. I nearly bought one as my spare EV for short trips nearby (they can be had for 1.5k NZD here). But minivan is just more useful for short trips, and doesn't break a bank either.

Same here. To be fair, we do have to put up with charging compatibility shenanigans. But that aside, I love this thing.

Reply on news.ycombinator.com